Rev. 10.19.11_41
iVS Series
1 of 12
Embedded Power for
Business-Critical Continuity
Intelligent VS Power
Up to 4920 Watts
Special Features
•FullmedicalEN60601approval
•IntelligentI2C control
•Voltageadjustmentonalloutputs
(manualorI2C)
•Configurableinputandoutput
OKsignalsandindicators
•Configurableinhibit/enable
•ConfigurableoutputUP/DOWN
sequencing
•Highpowerdensity(12W/cu-in)
•Intelligentfan(speedcontrol/
fault status)
•uPcontrolledPFCinputwith
activeInrushprotection
•I2Cmonitorofvoltage,current,
and temperature
•Programmablevoltage,current
limit,inhibit/enablethroughI2C
•Optionalextendedhold-up
module (SEMIF47compliance)
•Increasedpowerdensityto150%
•Optionalconformalcoating
•Industrialtemprange(-40ºCto
70ºC)
•UsesstandardiMP modules
•Fieldupgradeablefirmware
•RoHScompliant
Total Power: Up to 4920 Watts
Input Voltage:85-264Vdc
120-300Vdc
# of Outputs: Up to 24
Electrical Specifications
Safety
• UL UL60950/UL2601
• CSA CSA22.2No.234Level5
• VDE EN60950/EN60601-1
• BABT CompliancetoEN60950/
EN60601BS7002
• CB Certificate and report
• CE MarktoLVD
Font: Minion Bold for VS
Minion italic for i ; size for each is the same
Created on Mac
Color: "i" 100% Blue, 50% Magenta,
0% Yellow, 0% Black
"VS" - 100% Black
TM
Input
Inputrange:
iVS1&iVS3 90-264Vac1Ø;120-300Vdc
iVS6&iVS8 170-264Vac3Ø
Frequency: 47-440Hz
Inrushcurrent: 40Apeakmaximum(softstart)
Efficiency: Upto85%@fullcaseload
PowerFactor: 0.99typ.meetsEN61000-3-2
Turn-ontime: ACon1.5sectypical,inhibit/enable150mstypicalProgrammable;
50msinternalturn-ondelay(DualOutputonly)
EMIFilter: CISPR22/EN55022Level“B”
Leakagecurrent: 500µAmax.@240Vac;47-63Hz
RadiatedEMI: CISPR22/EN55022Level“B”
Holdoverstorage: 10msminimum(independentofinputVac)additional20mSEC
holdoverstoragewithoptionalHUPmodule
(SEMIF47compatible)
ACOK: >5msearlywarningminutesbeforeoutputsloseregulationFullcycle
ridethru(50Hz).Programmable
Harmonicdistortion: MeetsEN61000-3-2
Isolation: MeetsEN60950andEN60601
Globalinhibit/enable: TTL,Logic“1”andLogic“0”;configurable
Warranty: 3years
313
process
yellow
3405
1797
1375
116
2607
652
242
2985
375
240
Embedded Power for
Business-Critical Continuity
313
process
yellow
3405
1797
1375
116
2607
652
242
2985
375
240
Output
Adjustment range:* ±10%minimumalloutputs(manual)
(fullmoduleadjustmentrangeusingI2C)
Factorysetpointaccuracy: 1%
I2Coutputprogramaccuracy: ± 5%
Margining: ±4-6%nominalanalog(singleoutputmoduleonly)
Overallregulation: 0.4%or20mVmax.(1500Wmodules1%max.)
Ripple: RMS:0.1%or10mV,whicheverisgreater
Pk-Pk:1.0%or50mV,whicheverisgreater
Bandwidthlimitedto20MHz
Dynamicresponse: <2%or100mV,with25%loadstep
Recoverytime: Towithin1%in<300µsec
Overcurrent protection:** ConfigurablethroughI2C(calibrationrequired).Singleoutputmoduleand
mainoutputofthedualoutputmodule105-120%ofratedoutputcurrent.
Auxoutputofdualoutputmodule105-140%ofratedoutputcurrent.
SpecialprogrammableOCPdelayon1500Wmodulefrom100mSecto
25.5secondswithshutdownfeatures.
Short-circuitprotection: Protectedforcontinuousshort-circuit.
Recoveryisautomaticuponremovalofshort
(Shutdownmodeon1500Wmodule).
Overvoltage protection:* ConfigurablethroughI2C
Singleoutputmodule: 2-5.5V122-134%;6-60V110-120%
Dualoutputmodule: 2-6V122-134%;8-28V110-120%
Tripleoutputmodule: Noovervoltageprotectionprovided
Thermal protection:* ConfigurablethroughI2C
Alloutputsdisabledwheninternaltempexceedssafeoperatingrange.>
5mswarning(ACOKsignal)beforeshutdown
Remotesense: Upto0.5Vtotaldrop(notavailableontripleoutputmodule)
Singlewireparallel: Currentsharetowithin2%oftotalratedcurrent
DCOK:* +/-5%ofnominal.ConfigurablethroughI2C
Minimumload: Notrequired
Housekeepingbiasvoltage: 5Vdc@1.0Amax.presentwheneverACinputisapplied
Module inhibit:* ConfiguredandcontrolledthroughI2C
Output/Outputisolation: >1Megohm,500V
* CanbecontrolledviaI2C
** ControlledviaI2Cbutrequiresloadcalibration(except1500Wmodule)
Operatingtemperature: -40°to70°Cambient.Derateeachoutput2.5%perdegreefrom50°to70°C.
( -20 °C start up)
Storagetemperature: -40°Cto85°C
Electromagneticsusceptibility: DesignedtomeetEN61000-4;-2,-3,-4,-5,-6,-8,-11Level3
Humidity: Operating;non-condensing10%to95%RH
Vibration: IEC68-2-6tothelevelsofIEC721-3-2
MTBFdemonstrated: >550,000hoursatfullload,220Vacand25°Cambientconditions
EnvironmentalSpecifications
Rev. 10.19.11_41
iVS Series
2 of 12
Embedded Power for
Business-Critical Continuity
Module Code 1 2 3 5 4—
Module Type Single Single Single Single Dual Triple
Maxoutputpower 210W 360W 750W 1500W 144W 36W
Maxoutputcurrent 35A 60A 150A 140A 10A 2 A
Outputvoltagesavailable* 2-60V 2-60V 2-60V 6-60V
8-15*,24-28;8-15*,8-15*;8
-15*,2-6;2-6,2-6;24-28,24-28;
24-28,2-6
8-15,8-15,2-6;8-15,8-15,8-15;8-
15,8-15,18-28;8-15,18-28,2-6
Standardvoltageincrements 25 25 25 18 16 18
Remotesense Yes Yes Yes Yes Yes Yes No
Remotemargin Yes Yes Yes Yes No No No
V-Program-I2C Control Yes Yes Yes Yes Yes Yes No
ActiveCurrentShare Yes Yes Yes Yes Yes No No
ModuleInhibit-I2C Control Yes Yes Yes Yes Yes Yes Yes
ModuleInhibit-Analog Yes Yes Yes Yes Yes No No
Overvoltage/Overcurrent
protection Yes Yes Yes Yes Yes Yes Yes
Minimum load required No No No No No No No
Slots occupied in any iVS case 123411
*Note:ContactFactoryforextendedrangedownto6V
Output Module Line-up Rev. 10.19.11_41
iVS Series
3 of 12
Dual
Single
210W
360W
750W
144W
1500W
Voltage Voltage
Code Single Output Module Code Dual Output*** Triple Output I2C
Adjustment
Ranges****
123 5 4 4 - - -
2V A35A 60A 150A —10A 10A — — 2 A 1.8-2.2
2.2V B35A 60A 150A —10A 10A — — 2 A 2.0 - 2.4
3V C35A 60A 150A —10A 10A — — 2 A 2.7-3.3
3.3V D 35A 60A 150A —10A 10A — — 2 A 3.0-3.6
5V E35A 60A 150A —10A 10A — — 2 A 4.5-5.5
5.2V F35A 60A 144A —10A 10A — — 2 A 4.7-5.7
5.5V G34A 58A 136A —10A 10A — — 2 A 5.0-6.1
6.0V H 23A 42 A 97.5A 140A 10A* 10A* — — 2 A 5.4-6.6
8.0V I 20 A 36A 84.4 A 140A 10A 4 A 1A 1A 1A 7.2-8.8
10V J18A 32A 75A 140A 10A 4 A 1A 1A 1A 9.0-11.0
11V K17A 31A 68A 136.3A 10A 4 A 1A 1A 1A 9.9-12.1
12V L17A 30A 62.5A 125A 10A 4 A 1A 1A 1A 10.8-13.2
14V M14A 21A 53.5A 107A 9 A 4 A 1A 1A 1A 12.6-15.4
15V N 14A 20 A 50A 100A 8 A 4 A 1A 1A 1A 13.5-16.5
18V O11A 19A 41.6A 83.3A — — — 0.5A 0.5A 16.2-19.8
20V P10.5A 18A 37.5A 75A — — — 0.5A 0.5A 18.0-22.0
24V Q8.5A 15A 30A 62.5A 4 A 2 A —0.5A 0.5A 21.6-26.4
28V R 6.7A 11A 26.8A 53.5A 3A 2 A —0.5A 0.5A 25.2-30.8
30V S6.5A 11A 25A 50A — — — — — 27.0-33.0
33V T6.2A 10.9A 22.7A 35.8A — — — — — 29.7-36.3
36V U5.8A 10A 20.8 A 35.8A — — — — — 32.4-39.6
42V V 4.2 A 7.5A 16A 35.7A — — — — — 37.8-46.2
48V W4.0 A 7.5A 15.6A 31.2A — — — — — 43.2-52.8
54V X3.7A 6.0A 13.9A 27.7A — — — — — 48.6-59.4
60V Y3.5A 6.0A 12.5A 25A — — — — — 54.0-66.0
Contact Factory
Special* Z35A 60A 150A — — 10A 2.3-2.6
Special* Z35A 60A 150A — — 10A 3.7-4.4
Special* Z20 A 36A 80 A 140A —8 A 6.7-7.1
*Note:ContactFactoryforextendedrangedownto6V.
**Incrementsofcurrentnotshowncanbeachievedbyparallelingmodules(addcurrentsofeachmoduleselected).
***Totaloutputpowerondualmodelmustnotexceed144W.
****Forsingleoutputmodulesonly.
OutputModuleVoltage/Current*
Triple
36W
313
process
yellow
3405
1797
1375
116
2607
652
242
2985
375
240
iVS1 - 5L1 -1Q1 - 2EO - 4LL0 - 00 - A - ###
Rev. 10.19.11_41
iVS Series
4 of 12
Embedded Power for
Business-Critical Continuity
OrderingInformation
Samplebelowis3210Wcasewith12V@125A;24V@8.5A;5V@60A;12V@10Aand12V@4A;withnooptions.
Case Size (mm)
1-Phase Input
1 = 5”x5”x11”;1500W-3210W,9Slots
(127x127x279.4)
3 = 5”x8”x11”;1800W-4500W,14Slots
(127x203.2x279.4)
3-Phase Input
6 = 5”x5”x11”;3120W,9Slots
(127x127x279.4)
8 = 5”x8”x11”;4920W,14Slots
(127x203.2x279.4)
Module Codes:
(None)=36WtripleO/P(1slot)
1=210WsingleO/P(1slot)
2=360WsingleO/P(2slot)
3=750WsingleO/P(3slot)
5=1500WsingleO/P(slot4)
4=144WdualO/P(1slot)
HUP=Extra30mShold-up(1slot)
Voltage Codes:
SeeOutputModuleVoltage/Currenttable
Option Codes:
0 =Standard
1 =Moduleenable
2 =Constantcurrent
3 =1&2combined
4 =Setforuseinstandard(non-intelligentcase)
5 =Shutdownmodefor1500W
6 =1&5combined
7-9 Future
First Digit
0-9=Parallelcode
(See parallel codes table below)
Second Digit
0=Nooptions
1=Reverseair
2=Notused
3=Globalenable
4=FanOffw/inhibit
5=Opt1+Opt3
6=Opt1+Opt4
7=Opt3+Opt4
8=Opt1+3+4
9=CANBUS/RS48573-544-001
B=USB 73-546-001
M=Medical
N=M+1
P=M+3
R=M+1+3
Hardware Code
Module/Voltage/Option Codes
First - Module Code
Second-VoltageCode
Third-OptionCode
Case Option Codes
Software code used
forconfiguration
change.“A”is
standard
Case Size
Factory assembled
forhardwareof
firmware mods.
Software Code
OrderingNote:
1.USBtoI2C module order code
73-769-001
313
process
yellow
3405
1797
1375
116
2607
652
242
2985
375
240
Rev. 10.19.11_41
iVS Series
5 of 12
Embedded Power for
Business-Critical Continuity
OrderingInformationcontinued
313
process
yellow
3405
1797
1375
116
2607
652
242
2985
375
240
Parallel
Code
Slot No. iVS1, 6 iVS3, 8
Diagram Possible Configurations Diagram Possible Configurations
11&2 210210;210144;144144 210210;210144;144144
22&3 360360;360210;360144;+above 360360;360210;360144;+above
3 3&4 750360;750210;750144;210210;
210144;144144
750750;750360;750210;750144;
210210;210144;144144
44&5 1500210;1500144;210210;210144;
144144;360210;360144
15001500;1500750;1500360;1500210;
1500144;210210;210144;144144;360
360;360210;360144
5 3,4,&5 750210210;750210144;750144144 750210210;750210144;750144144
6 iVS1,6:4&6 15001500;1500750
7 4,5,&6 1500210210;1500210144;1500144
144
1500210210;1500210144;1500144
144
8iVS1,6:3&6
iVS3,8:4,5,&9
750750 150015001500;15001500750;1500
1500360;15001500210;15001500144
9iVS1,6:1&6
iVS3,8:4,5&9;12&13
15001500;1500360;1500144 150015001500360;150015001500210;
150015001500144
AiVS1,6:3&4;8&9
iVS3,8:4&5;11&12
750210&750210 15001500&750750
CiVS1,6:3,4&6
iVS3,8:6&7;3,4,11&12
750,360,750 750750360750750
EiVS1,6:3,4,6;8&9
iVS3,8:3,4,11,&12
750,360,750,210 750750750750
FiVS1,6:7-8
iVS3,8:3&4;11&12
360,360 750360&750210;750750&750750
GiVS3,8:3,4&9 750750750
H iVS3,8:11&12 750750
JiVS3,8:4&5;9&10 1500210&2101500
KiVS3,8:1&9;5&12 1500750&1500750
LiVS3,8:3&4;7&8;9&10 750210&750210&2101500
MiVS3,8:3,4&9;6&7 750750360750
6
54321
879AC
6
54321
879AC
6
54321
879AC
6
54321
879AC
6
54321
879AC
6
54321
879AC
6
54321
879AC
6
54321
879AC
6
54321
879AC
6
54321
879AC
6
54321
879AC
6
54321
879AC
6
54321
879AC
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
AC 14 13 12 11 10 9
87654321
Rev. 10.19.11_41
iVS Series
6 of 12
Embedded Power for
Business-Critical Continuity
Input
90-264Vac 170-264Vac
iVS3 = 5”x8”x11” 1800Wmax. 4500Wmax.
(127x203.2x279.4)
14availableslots
S
L
O
T
13
S
L
O
T
14
S
L
O
T
12
S
L
O
T
11
S
L
O
T
10
S
L
O
T
9
S
L
O
T
7
S
L
O
T
5
S
L
O
T
6
S
L
O
T
4
S
L
O
T
3
S
L
O
T
2
S
L
O
T
1
S
L
O
T
8
iVS1 and iVS6
iVSCaseSpecifications
6
110
5
Pin Connectors
1
2
3
~
N1
2
3
4
L
L
L
AC Input Single Phase 3 Phase
PinNo. Function
1AC neutral Line1
2ACline(hot) Line 2
3Chassis(earth)
ground Line3
4Chassis(earth)
ground
PFC Input Connector (control & signals)
PinNo. Function
1InputACOK-“emitter”
2InputACOK-“collector”
3 GlobalDCOK-“emitter”
4GlobalDCOK-“collector”
5 Noconnection
6 Globalinhibit/optionalenablelogic“0”
7 Globalinhibit/optionalenablelogic“1”
8Globalinhibit/optionalenablereturn
9+5VSBhousekeeping
10 +5VSBhousekeepingreturn
Mateswith
Molex90142-0010Housing
90119-2110Pin
ConnectorKitPartNo.:
70-841-004
Figure 1. AC Input Figure 2. Connector J1
S
L
O
T
9
S
L
O
T
7
S
L
O
T
8
S
L
O
T
6
S
L
O
T
4
S
L
O
T
2
S
L
O
T
3
S
L
O
T
1
S
L
O
T
5
Input
90-264Vac 170-264Vac
iVS1= 5”x5”x11” 1500Wmax. 3210Wmax.
(127x127x279.4)
9availableslots
iVS6= 5”x5”x11” N/A 170-264Vac
(127x127x279.4) 3210Wmax.
9availableslots
3-phaseonly
iVS3, and iVS8
10 6
51
I2C Bus Output Connector
PinNo. Function
1Noconnection
2Noconnection
3 Noconnection
4Serialclocksignal(SCL)
5 Serialdatasignal(SDA)
6Address bit 0 (A0)
7Addressbit1(A1)
8Address bit 2 (A2)
9Secondaryreturn(GND)
10 5VCCexternalbus(5VCCbus)
Mateswith
Landwin 2050S1000Housing
2053T011VPin
or
JSTPHDR-10VSHousing
JSTSPHD-002T-P0.5(28-24)
JSTSPHD-001T-P0.5(26-22)
ConnectorKitPartNo.:
70-841-023
Figure 3. Connector J2
1
2
3
~
N1
2
3
4
φ1
φ2
φ3
L L L
4231
iVS1,iVS3 iVS6
iVS8
iVS8= 5”x8”x11” N/A 170-264Vac
(127x203.2x279.4) 4920Wmax.
14availableslots
313
process
yellow
3405
1797
1375
116
2607
652
242
2985
375
240
Rev. 10.19.11_41
iVS Series
7 of 12
Embedded Power for
Business-Critical Continuity
DC-DCConverterOutputModules
ControlSignalInformation,J1ControlConnector
PinNo. Function
1 +RemoteSense singleordualo/pmain
2 RemoteMargin/V.Program singleo/p
3 MarginHigh singleo/p
4 -RemoteSense/MarginLow singleordualo/pmain
5 Spare
6 Module,IsolatedInhibit singleordualo/p
7 ModuleInhibitreturn singleordualo/p
8 CurrentShare(SWP) singleordualo/pmain
9 +RemoteSenseV2 dualo/p,singleisspare
10 -RemoteSenseV2 dualo/p,singleisspare
*Note:AlliMPmoduleshaveagreenDCOKLED.
(exceptfor36Wmodule)
.63”
(16.0)
.32”
(8.1)
1.38” (35.2)
(2X)
.44”
(11.4)
.48” (12.1)
(2X)
.33”
(8.5)
V ADJ
V-
V+
M 4 X 8 SCREWS WITH
CONICAL WASHER
DC OUTPUT CONNECTOR
PIN 1
.44"
(11.4)
.32"
(8.1)
1.38"
(35.1)
.48"
(12.1)
.44” (11.2)
2X
V+
M4X8 SCREWS WITH CONICAL WASHER
DC OUTPUT CONNECTOR
PIN 1
V-
V ADJ
PIN 1
V2 ADJ
.32
(8.1)
.42 (10.7)
V1 +
V1 -
V2 +
M3X8 SCREWS WITH SPRING WASHER
(4X)
.46 (11.7)
(4X)
.30 (7.5)(3X)
V1 ADJ
1.17 (29.7)
V2 -
Single210Watt
Dual144Watt
Single360Watt Single750Watt
iMP Modules
Triple36Watt
V1 ADJ
V2 ADJ
V3 ADJ
V1+
V3+
V1-
V2+
V2-
V3-
.32"
(8.1)
.44"
(11.0)
1.24"(11.0)
(2X)
.61"(15.6)
(2X)
.59"
(15.0)
.63"
(16.0)
V+
V-
M4X8 SCREWS
(4X)
V ADJ
PIN 1
DC OUTPUT
CONNECTOR
Figure 1. AC Input
1
2
3~
N
6
110
5
Figure 2. Connector J1
Mateswith
Molex90142-0010Housing
90119-2110Pin
Figure 4. Connector J1
V1 +
V1 -
V2 -
V3 -
V3 +
V2 +
Mateswith
Molex09-91-0600Housing
26-60-5060Pin
Single1500Watt
V-
V+
59.3 ± 0.2
(2x) 15.0 ±0.8
(2x) 16.0 ±0.2
(2x) 16.0 ±0.2
(3x) 31.6 ±0.8
11.3 ±0.8
8.1 ±0.8
DC OUTPUT CONNECTOR
PIN 1
M4X8 SCREWS W/
CONICAL WASHER (6X)
For Factory-Use Only
VADJ
313
process
yellow
3405
1797
1375
116
2607
652
242
2985
375
240
Rev. 10.19.11_41
iVS Series
8 of 12
Embedded Power for
Business-Critical Continuity
AC INPUT
CONNECTOR
AC INPUT
CONNECTOR
AC INPUT
CONNECTOR
127.0 ± 0.5
OUTPUT MODULE
AREA
B
N
C
C
A
B
C
A
B
12.7
101.6 ± 0.9
127.0 ± 0.9
279.40 ± 1.27 127.0 ± 0.5
127.0 ± 0.9
19.1 171.5
57.4
13.5 12.0
33.5
65.5
11.6
63.5
“MOUNTING HOLES DIMENSIONS IDENTICAL ON BOTH SIDES”
I2C
CONNECTOR
SELV CONTROL
CONNECTOR
USB PROGRAMMING
CONNECTOR OPTION
AC OK
LED
DC OK
LED
171.45
29.05
12.70
114.30
19.05
22.80
171.45
5.00
L
PE
M4 MTG HOLES 4 PL
FAN
92 X 92 X 38mm
REVERSE AIRFLOW DIRECTION
NORMAL AIRFLOW DIRECTION
iVSSeries
iVS1(1500/3210 WattsMax)
5-InchCaseSize:iVS1:5”x5”x11”(127mmx127mmx279.4mm)
Weight:iVS1Case:6.2lbs.•1500WSingle:2.0lbs.•750WSingle:1.6lbs.
•360WSingle:1.0lb.•210WSingle:0.6lb.•144WDual:0.6lb.
Notes
1. Input:Barriertype.ThreeNo.6-32B.H.screws(0.375”centers).Maxtorque:6in-lbs.(0.67N-m).
2. Controlconnectors:(J1)10positionhousing,goldplatedcontacts.MateswithMolex90142-0010housingwith90119-2110crimpcontacts(MolexC-GridIIISeries).
Connectorkitincludesmatingconnectorand10pins,Astecpart#70-841-004.(J2)10positionhousing(Landwin2051P1000T).Mateswithhousing2050S1000
(Landwin)with2053T011P(Landwin)pins.
3. Chassismaterial:aluminumwithchemicalfilmcoating(conductive).
4. Alldimensionsareinmillimetersandinches,andaretypical.
5. Customermounting-3sidesM4,bottomalsoincludes8-32mountingholes.Max.penetrationis0.155”(4.0mm).Max.torque:5in-lbs.(0.57N-m).
6. Outputmoduleconnections:AllsingleO/PmodulesareM4x8mmscrews.Max.torque:10in-lbs.(1.13N-m).
DualO/PmoduleisM3x8mmscrews.Max.torque:5in-lbs.(0.57N-m).
313
process
yellow
3405
1797
1375
116
2607
652
242
2985
375
240
Rev. 10.19.11_41
iVS Series
9 of 12
Embedded Power for
Business-Critical Continuity
AC INPUT
CONNECTOR
101.6 ± 0.9
OUTPUT MODULE
AREA
A19.1
279.4±1.27
12.7
USB PROGRAMMING
CONNECTOR OPTION
I2C
SELV CONTROL
CONNECTOR
C
B
A
171.45
A
C
B
B
C
M4 MTG HOLES 4 PL
“MOUNTING HOLES DIMENSIONS IDENTICAL ON BOTH SIDES
#8-32 MTG HOLES
5PL
MARKED “A”
6, 7 REF
203.2±0.5
127±0.9
98
52.6
42
61.2
81.5
11.6
65.5
DC OK LED AC OK LED
FAN
80 X 80 X 38mm
29.1 171.5
16.2
19.1 171.5
12.7
177.8
173.3
149.4
14.4
M4 MTG HOLES
5 PL
MARKED “B”
A
BA
BA
A
A
A
B
B
B
SLOT 9
SLOT 10
SLOT 11
SLOT 12
SLOT 13
SLOT 14
SLOT 1
SLOT 2
SLOT 3
SLOT 4
SLOT 5
SLOT 6
SLOT 7
SLOT 8
REVERSE AIRFLOW DIRECTION
NORMAL AIRFLOW DIRECTION
8-InchCaseSize:iVS3:5”x8”x11”(127mmx203.2mmx279.4mm)
Weight:iVS3Case:9.0lbs.•1500WSingle2.0lbs.•750WSingle:1.6lbs.
•360WSingle:1.0lb.•210WSingle:0.6lb.•144WDual:0.6lb.
iVSSeries
iVS3(1800/4500 WattsMax)
Notes
1. Input:Barriertype.ThreeM4screws(0.512”centers).Maxtorque:7in-lbs.(0.79N-m).
2. Controlconnectors:(J1)10positionhousing,goldplatedcontacts.MateswithMolex90142-0010housingwith90119-2110crimpcontacts(MolexC-GridIIISeries).
Connectorkitincludesmatingconnectorand10pins,Astecpart#70-841-004.(J2)10positionhousing(Landwin2051P1000T).Mateswithhousing2050S1000
(Landwin)with2053T011P(Landwin)pins.
3. Chassismaterial:aluminumwithchemicalfilmcoating(conductive).
4. Alldimensionsareinmillimetersandinches,andaretypical.
5. Customermounting-3sidesM4,bottomalsoincludes8-32mountingholes.Max.penetrationis0.155”(4.0mm).Max.torque:5in-lbs.(0.57N-m).
6. Outputmoduleconnections:AllsingleO/PmodulesareM4x8mmscrews.Max.torque:10in-lbs.(1.13N-m).
DualO/PmoduleisM3x8mmscrews.Max.torque:5in-lbs.(0.57N-m).
313
process
yellow
3405
1797
1375
116
2607
652
242
2985
375
240
Rev. 10.19.11_41
iVS Series
10 of 12
Embedded Power for
Business-Critical Continuity
279.4±1.0
63.5
DC OK
LED
5.0±0.5
293.0±1.2
127.0±0.5
65.5
11.6
(2X)
12.0
57.4
33.5
13.5
127.0±0.9
AC OK
LED
FOR M4 SCREW (4X)
(FOR SYSTEM MOUNTING)
USB PROGRAMMING
CONNECTOR OPTION
I
2
C CONNECTOR
SELV CONTROL
CONNECTOR
171.5 (2X)
19.1 (2X)
101.6±0.9 (2X)
12.6±0.6
12.7 (4X) 12.7 (2X)
INTERNAL FUSES
15A/250V
GND
AC INPUT
CONNECTOR
171.5 (2X)
19.1 (2X)
L3
L2
L1
SLOT 9
SLOT 8
SLOT 4
SLOT 5
SLOT 6
SLOT 7
SLOT 1
SLOT 2
SLOT 3
101.6±0.9 (2X)
12.7 (2X)
19.1 (2X) 171.5 (2X)
FOR M4 SCREW (4X)
(FOR SYSTEM MOUNTING)
L3
L2
L1
FOR #8-32 SCREW (4X)
(SYSTEM MOUNTING)
12.7 (4X)
29.1 (2X)
171.5 (2X)
FOR M4 SCREW (4X)
(FOR SYSTEM MOUNTING)
20.3±0.6
REVERSE AIRFLOW DIRECTION
NORMAL AIRFLOW DIRECTION
5-InchCaseSize:iVS6:5”x5”x11”(127mmx127mmx279.4mm)
Weight:iVS6Case:6.0lbs.•1500WSingle2.0lbs.
•750WSingle:1.6lbs.•360WSingle:1.0lb.
•210WSingle:0.6lb.•144WDual:0.6lb.
iVSSeries
iVS6(3210 WattsMax)
Notes
1. Input:Barriertype.FourM3screws(0.325”centers).Maxtorque:6in-lbs.(0.67N-m).
2. Controlconnectors:(J1)10positionhousing,goldplatedcontacts.MateswithMolex90142-0010housingwith90119-2110crimpcontacts(MolexC-GridIIISeries).
Connectorkitincludesmatingconnectorand10pins,Astecpart#70-841-004.(J2)10positionhousing(Landwin2051P1000T).Mateswithhousing2050S1000
(Landwin)with2053T011P(Landwin)pins.
3. Chassismaterial:aluminumwithchemicalfilmcoating(conductive).
4. Alldimensionsareinmillimetersandinches,andaretypical.
5. Customermounting-3sidesM4,bottomalsoincludes8-32mountingholes.Max.penetrationis0.155”(4.0mm).Max.torque:5in-lbs.(0.57N-m).
6. Outputmoduleconnections:AllsingleO/PmodulesareM4x8mmscrews.Max.torque:10in-lbs.(1.13N-m).
DualO/PmoduleisM3x8mmscrews.Max.torque:5in-lbs.(0.57N-m).
313
process
yellow
3405
1797
1375
116
2607
652
242
2985
375
240
Rev. 10.19.11_41
iVS Series
11 of 12
Embedded Power for
Business-Critical Continuity
MOSYTEM Mounting
for M4 Screw (I3X) (’a’)
127.0±0.2
REVERSE AIRFLOW DIRECTION
NORMAL AIRFLOW DIRECTION
6.8 max
(2x)
203.2±0.2
127.0±0.2
65.5 (2x)
11.6 (2x)
155.6
52.6
31.8 7
72.1
50.7
USB Programming
Connector Option
SELV Control
Connector
I2C Connector
MOSYTEM Mounting
for M4 Screw (I3X) (’a’)
MOSYTEM Mounting
for M4 Screw (I3X) (’a’)
12.7 (2x) 12.7 (2x)
12.7 (2x)
MOSYTEM Mounting for
#8-32 Screw (5X) (’a’)
291.1±1.2
279.4±0.2
12.7 (2x)
101.6±0.9
19.1 (2x)
171.5 (2x)
171.5 (2x)
19.1 (3x)
171.5 (2x)
29.1 (3x)
15.5 (2x)
23.9 (2x)
14.4 (2x)
AC Input
Connector
GND
Terminal
101.6±0.9
12.7 (2x)
19.1 (2x) 171.5 (2x)
iVSSeries
iVS8(4920 WattsMax)
8-InchCaseSize:iVS8:5”x8”x11”(127mmx203.2mmx279.4mm)
Weight:iVS8Case:9.0lbs.•1500WSingle2.0lbs.
•750WSingle:1.6lbs.•360WSingle:1.0lb.
•210WSingle:0.6lb.•144WDual:0.6lb.
Notes
1. Input:Barriertype.ThreeM3.5screws(0.394”centers).Maxtorque:6in-lbs.(0.67N-m).
2. Controlconnectors:(J1)10positionhousing,goldplatedcontacts.MateswithMolex90142-0010housingwith90119-2110crimpcontacts(MolexC-GridIIISeries).
Connectorkitincludesmatingconnectorand10pins,Astecpart#70-841-004.(J2)10positionhousing(Landwin2051P1000T).Mateswithhousing2050S1000
(Landwin)with2053T011P(Landwin)pins.
3. Chassismaterial:aluminumwithchemicalfilmcoating(conductive).
4. Alldimensionsareinmillimetersandinches,andaretypical.
5. Customermounting-3sidesM4,bottomalsoincludes8-32mountingholes.Max.penetrationis0.155”(4.0mm).Max.torque:5in-lbs.(0.57N-m).
6. Outputmoduleconnections:AllsingleO/PmodulesareM4x8mmscrews.Max.torque:10in-lbs.(1.13N-m).
DualO/PmoduleisM3x8mmscrews.Max.torque:5in-lbs.(0.57N-m).
313
process
yellow
3405
1797
1375
116
2607
652
242
2985
375
240
Rev. 10.19.11_41
iVS Series
12 of 12
Embedded Power for
Business-Critical Continuity
Americas
5810VanAllenWay
Carlsbad,CA92008
USA
Telephone:+17609304600
Facsimile: +17609300698
Europe (UK)
Waterfront Business Park
MerryHill,Dudley
WestMidlands,DY51LX
UnitedKingdom
Telephone:+44(0)1384842211
Facsimile: +44(0)1384843355
Asia (HK)
14/F,LuPlaza
2WingYipStreet
KwunTong,Kowloon
HongKong
Telephone:+85221763333
Facsimile: +85221763888
Forglobalcontact,visit:
www.Emerson.com/EmbeddedPower
techsupport.embeddedpower
@emerson.com
Whileeveryprecautionhasbeentakentoensure
accuracyandcompletenessinthisliterature,Emerson
NetworkPowerassumesnoresponsibility,anddisclaims
allliabilityfordamagesresultingfromuseofthis
information or for any errors or omissions.
EmersonNetworkPowerandtheEmerson
NetworkPowerlogoaretrademarksand
servicemarksofEmersonElectricCo.
©2011EmersonElectricCo.
EmersonNetworkPower.com
EmbeddedComputing
Embedded Power
Monitoring
Outside Plant
PowerSwitching&Controls
PrecisionCooling
Racks&IntegratedCabinets
Services
SurgeProtection
Emerson Network Power.
Thegloballeaderinenabling
business-critical continuity.
AC Power
Connectivity
DCPower
313
process
yellow
3405
1797
1375
116
2607
652
242
2985
375
240
OptionalCANBUSorRS485Interface
TheRS485/CAN-to-I2Cuses2InputProtocolsand1OutputProtocol.
TheInputProtocolsusedareRS485usingModbus(CommandIndex:0x01),andCANusingmodified
Modus(CommandIndex:0x02).
TheOutputProtocoluseis:I2CwithSMBussupport(CommandIndex:0x80).
Master/Client Device(s)
Adapter
Output Protocols
Slave/Server Device(s)
Adapter Protocol
Input Protocols
Ad
ap
t
er
C
omman
d
RS485 using
Modbus
A
d
a
p
ter Contro
l
s
CAN using
Modified Modbus
I2C with SMBus
Support
RS485/CAN-to-I2C
ForDetailedInfo,DownloadtheSoftwareRequirementsSpecification(SRS)from
www.PowerConversion.com/products/cat/103/iVS-series-ac-dc-power-supplies
iVS CAN RS485 iVS I2C USB